Manitowoc S model Installation, Use & Care Manual

Also see for S model: Use and care manual Installation, use & care manual Installation, use & care manual Service manual Installation, use & care manual

Contents

Manitowoc S model Installation, Use & Care Manual Manual pdf 7 page image

Section 2 Installation InstructionsPart Number 000007646 11/10 7Installation Procedures1. Review the Pre-Installation Checklist; then makesure all utility and space requirements are present atthe installation site.2. Remove the carton top from the dispenser.3. Remove the legs and other accessories from insidethe dispenser bin.4. Remove the carton from the sides of the dispenser.5. Remove the dispenser from the shipping pallet.6. Flatten the shipping carton.7. Lay the dispenser on its back; on the carton.8. Thread the legs into the bottom of the dispenser.9. Set the dispenser upright.10. Place the dispenser in the desired location.11. Make sure the dispenser bin top is level. A level binis important for proper operation of the ice machine.12. Place the ice machine on top of the dispenser at thistime.13. Connect the drain of the dispenser to the floor drain.14. Follow local plumbing codes for drain installation.15. If the dispenser has a water valve, connect yourwater line to the water connection at the back of thedispenser.16. Test all drain and water lines for leaks.17. Plug the dispenser into the proper electrical outlet.18. Clean and sanitize all equipment. Follow cleaningand sanitizing instructions in this manual.19. Adjust the ice machine according to the instructionsprovided with the ice machine.20. Install ice baffle inside the ice maker compartment.Follow installation instructions supplied with icebaffle.21. Install foam gasket on the bottom of the front panel.22. Fill the dispenser bin one quarter full of ice or startthe ice machine, allowing the ice machine to drop atleast three complete batches of ice.23. Test the ice dispensing action of the dispenser.Installation Checklist! WarningDo not attempt to move a dispenser without firstremoving the ice machine. The combination can beunstable and could tip, causing serious injury.Dispenser and ice machine are level?Drains are vented?Dispenser does not sit in direct sunlight?Dispenser does not sit in direct airflow from aheating duct?Bin and ice machine drains are separate?Ice dispensed properly?Dispenser is accessible for servicing?The warranty card was returned?Ice Machine ice thickness control is properlyset?Owner was instructed on the operation of thedispenser?Owner knows how to clean and sanitize thedispenser?Owner knows how often to clean and sanitizethe dispenser?Owner has your telephone number to call forfollow-up service on the dispenser?You have placed one of your service stickers onthe dispenser for follow-up service?