U-Line 2015WC Wine Captain Installation Manual

Also see for 2015WCOL Wine Captain: Supplementary guide Supplementary guide Features & benefits User manual Hardware installation guide

Contents

U-Line 2015WC Wine Captain Installation Manual Manual pdf 12 page image

2015WC/2015WCOL Wine Captain®www.U-LineService.com 12 02/2005™Checking Door AlignmentThe unit’s door is aligned at the factory before shipment.However, its alignment could have been disturbed duringshipment or during overlay frame installation.IMPORTANTProperly aligned, the door should be 1/8" below the top ofthe unit’s cabinet, NOT flush with the top (see Figure 23).1. Compare the top edge of the door to the top edge ofthe cabinet.2. If the door edge is 1/8" below and parallel to the top ofthe cabinet, go on to 6 Prepare Power Supply. If it isnot, note whether the side opposite the hinge needs tobe moved UP or DOWN, and use the followingprocedure.Adjusting Door Alignment1. Remove top hinge screwpin (7/64 " Allen wrench orPhillips screwdriver,depending on your unit’sconstruction, seeFigure 24). Remove doorby tilting forward andlifting off bottom hingepin.2. With door upside-down,loosen but do not removethe two screws on the door’s bottom hinge plate.3. See Figure 25. If the top far edge of the door needs tomove UP, move the hinge plate toward the outside ofthe door and retighten screws. If the top far edge of thedoor needs to move DOWN, move the hinge platetoward the inside of the door and retighten screws.4. Mount the door to recheck alignment and repeatSteps 2 and 3 if further adjustment is necessary.5. When top edge of door is parallel to top edge ofcabinet, remove the door and ensure the two screwsare secure.6. Remove the door closers from the bottom hinge, cleanthoroughly and lubricate the mating surfaces withpetroleum jelly.7. Reinstall the closers, liningup the bosses with holes inhinge and hinge plate (seeFigure 26).8. Mount the door, install tophinge pivot pin and go onto 6 Prepare PowerSupply.5 Adjust Door1/8"Figure 23Figure 24Angled EdgeTowards Centerof DoorSlottedMountingHolesRaiseOutsideDoor EdgeLowerOutsideDoor EdgeFigure 25DoorCloserInsertsBossFigure 26