Sealey AK459DX.V2 Manual

Also see for AK459DX.V2: Instructions

Gravity & suction feed/air discharGeoil drainermodel no: aK459dX.v2thank you for purchasing a sealey product. Manufactured to a high standard, this product will, if used according to these instructions,and properly maintained, give you years of trouble free performance.iMportant: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USETHE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/ORPERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.1. safety WarninG: ensure Health & Safety, local authority, and general workshop practice regulations are adhered to when using thisequipment.9 Familiarise yourself with the application and limitations of the oil drainer, as well as the potential hazards. WarninG: disconnect the drainer from the air supply before changing accessories, servicing or performing any maintenance.9 maintain the drainer in good condition (use an authorised service agent).9 Replace or repair damaged parts. Use genuine parts only. Unauthorised parts may be dangerous and will invalidate the warranty.9 Keep the work area clean, uncluttered and ensure there is adequate lighting.9 Keep the drainer clean for best and safest performance.9 maintain correct balance and footing. ensure the floor is not slippery and wear non-slip shoes.9 Keep children and unauthorised persons away from the working area. WarninG: ensure correct air pressure is maintained and not exceeded.9 Keep air hose away from heat, oil and sharp edges. Check air hose for wear before each use, and ensure that all connections aresecure.8 do not use the drainer for any purpose other than that for which it is designed.8 do not operate the drainer if any parts are damaged or missing as this may cause failure and/or personal injury.8 do not stand on the drainer.8 do not adjust or tamper with the safety valve.8 do not move the drainer by the hose, or pull the hose sharply from the air supply.8 do not place attachments close to your face and do not point hose at other persons or animals.8 do not allow untrained persons to operate the drainer.8 do not operate the drainer when you are tired, under the influence of alcohol, drugs or intoxicating medication.8 do not leave the drainer operating unattended.8 do not direct air from the air hose at yourself or others.9 When not in use disconnect from the air supply, vent reservoir and store in a safe, dry, childproof area.9 dispose of waste oil in accordance with local authority regulations. WarninG: do not pollute the environment by allowing uncontrolled discharge of waste oil.2. i introductionSteel fabricated 90ltr reservoir and telescopic steel drain pan fitted with filter grid. Venturi suction pump powers oil dipstick probesand includes a set of quick release probes. Gravity or suction feed reservoir with air discharge. Fitted with oil level indicator tube.Supplied with mercedes adaptor.3. i specificationModel no:........................................................aK459dX.v2Capacity: ........................................................................ 90ltrminimum Height to Pan: .......................................... 1300mmmaximum Height to Pan: ......................................... 1750mmGravity Feed: .................................................................. YesSuction Feed: .................................................................. YesGravity discharge: ........................................................... noAir discharge: ................................................................. YesPump discharge ............................................................... no4. air supply4.1. Recommended hook up is shown in fig.1.4.2. Ensure the air valve is in the “Off” position before connecting to the air supply.4.3. You will require an air pressure of 7 bar. WarninG: ensure the air supply is clean and does not exceed pressuresspecified in these Instructions. Too high an air pressure and/or unclean air willshorten the drainer life due to excessive wear, and may be dangerous.AK459dX.V2 Issue 2 19/11/18Original Language Version© Jack Sealey limitedRefer toinstructionmanualWear protectivegloves Wear eyeprotection Wear protectiveclothingfig.1

/ 4

Related manuals for Sealey AK459DX.V2