Manitowoc SM Model Installation, Use & Care Manual

Also see for SM: Installation use and care manual Installation, use & care manual

Manitowoc SM Model Installation, Use & Care Manual Manual pdf 18 page image

Maintenance Section 418 Part Number 040001361 05/10Top Cover1. Remove two back screws.2. Slide back and lift cover off.Water ShuttersThe water shutter is designed to keep the spraying waterfrom escaping the evaporator compartment.To remove just the water shutters:1. Grasp one end of the water shutter and lift up.2. Pivot water shutter and disengage remaining end.3. To re-install into ice machine, grasp one end of thewater shutters, install one end, pivot the oppositeend and pull down into position. Make sure tabs aresecure in grooves.To remove water shutter assembly:1. Slide evaporator bucket forward 1/2” (13 mm).2. Lift shutter assembly straight up.Bin LightIf the ice machine is shut down for a long period of timethe bin light cover must be cleaned and sanitized. Thelight is provided for your convenience. If you experienceoperational problems with the light a replacementappliance bulb can be obtained from your local hardwarestore.Front Grill1. Remove two screws.2. Tilt top forward and lift.Ice ChuteThe ice chute is positioned over the spray nozzles andallows the ice to easily fall into the bin. It must be firmlypositioned over the spray bar, with the front edge insidethe water trough. Spray nozzles must be align with thespray holes or spray water will fall into the bin.1. Grab protruding spray hole on one end and lift upand remove.2. To re-install ice chute, grasp protruding spray holeand position over Water Distribution Assembly.Make sure rear supports are over spray bar, andfront edge is inside of water trough.! WarningDisconnect the electrical power to the ice machineat the electrical disconnect before proceeding.! WarningRemoving the water shutters while the water pumpis running will allow water to spray from icemachine. Disconnect the electrical power to the icemachine at the electric service switch box and turnoff the water supply.ShutterAssemblyWaterShuttersGraspWaterShuttersHere! WarningDisconnect the electric power to the ice machine atthe electric service switch box and turn off the watersupply before proceeding.