red lion CUB7 Series Manual

Also see for CUB7 Series: Data Sheet / Manual

Contents

red lion CUB7 Series Manual Manual pdf 1 page image

11.64 (41.6)0.87(22.1)1.10(27.9)2.00 (50.8) 2.17 (55)With Wires With Terminal Blockl 0.35" (8.9 mm) HIGH LCD DIGITS, REFLECTIVE OR TRANSMISSIVEWITH YELLOW/GREEN OR RED BACKLIGHTING (6-26 VDC powersupply required for version with LED backlighting)l INTERNAL LITHIUM BATTERY PROVIDES UP TO 7 YEARS OFTYPICAL UNINTERRUPTED OPERATIONl COUNT SPEEDS UP TO 10KHZl 9 PROGRAMMABLE TIME RANGESl CONTACT, LOGIC, OPEN COLLECTOR, OR HIGH VOLTAGE INPUTSl STANDARD WIRE CONNECTIONS OR OPTIONAL PLUG-IN TERMINALBLOCKl NEMA 4X/IP65 SEALED FRONT BEZEL THAT FITS 1/32 DIN CUT-OUTDESCRIPTIONThe CUB7 series is an 8-digit lithium battery powered miniature counter ortimer with large 0.35" (8.9 mm) high digits. It has an LCD read-out available inPositive Imagine Reflective, Negative Image Transmissive with yellow/green orred backlighting. The backlight versions require an external 6-26 VDC powersupply. The CUB7 series is housed in a lightweight, high impact plastic casewith a clear viewing window. The sealed front panel with silicon rubber keypadmeets NEMA 4X/IP65 specification for wash-down and/or dusty environments,when properly installed with supplied panel gasket and mounting clip.Both counter and timer CUB7 models are available with a low voltage input(28 VDC max) or an isolated high voltage input (50-250 VDC/VAC). The lowvoltage input has DIP switch selections for SINKING or SOURCING alongwith a HIGH/LOW FREQUENCY selection (low frequency for contact inputs).Both units have front panel keypads that can be used to reset the display. Thekeypad can be enabled/disabled via a single DIP switch. The standard unit uses22 gauge wires for external connections, an optional plug-in terminal block isavailable.SAFETY SUMMARYAll safety related regulations, local codes and instructions that appear in theliterature or on equipment must be observed to ensure personal safety and toprevent damage to either the instrument or equipment connected to it. Ifequipment is used in a manner not specified by the manufacturer, the protectionprovided by the equipment may be impaired.SPECIFICATIONS1. DISPLAY: 8-digit LCD, 0.35" (8.90 mm) high digits2. POWER: Non-replaceable internal 3.6 VDC lithium battery provides 7 yearsof typical continuous operation (high count speeds in SNK mode & extremeambient temperatures will decrease battery life, use of SRC mode can extendbattery life)OPTIONAL LED BACKLIGHT POWER: 6-26 VDC @ 25 mA max.Must use an NEC Class 2 or Limited Power Source (LPS) rated power supply.Note: External power shall incorporate disconnecting device (switch or circuitbreaker) and provide Double/Reinforced isolation from MAINS supply.3. LOW VOLTAGE INPUT:COUNTERS: CUB7CCS0, CUB7CCR0, CUB7CCG0SNK mode (DIP switch 1 off, internal pull-up to battery)VIN High Min = 1.25 VDC; VIN Low Max = 0.45 VDCIIN Max = 8 μA; VIN Max = 3.6 VDCCount Speed: (count on negative edge)High freq mode (DIP switch 2 off): max 5 kHz @ 50% duty cycleLow freq mode (DIP switch 2 on): max 30 Hz @ 50% duty cycleNote: The three models listed above may be used for count inputs with10-50 VAC signals when using a VCM10000 converter module. DIPswitches must be set for SNK and Low frequency.SRC mode (DIP switch 1 on, internal 20 kW pull-down to common)VIN High Min = 1.25 VDC; VIN Low Max = 0.45 VDCIIN Max = 5 mA; VIN Max = 28 VDCCount Speed: (count on negative edge)High freq mode (DIP switch 2 off): max 10 kHz @ 50% duty cycleLow freq mode (DIP switch 2 on): max 50 Hz @ 50% duty cycleTIMERS:Models: CUB7TCS0, CUB7TCR0, CUB7TCG0 For these models, theunit will time when the CUB7 input is low.SNK mode (DIP switch 1 off, internal pull-up to battery)VIN High Min = 1.25 VDC; VIN Low Max = 0.45 VDCIIN Max = 8 μA; VIN Max = 3.6 VDCNote: The three models listed above may be used with 10-50 VACMODEL CUB7 – MINIATURE ELECTRONIC 8 DIGIT COUNTER or TIMERDIMENSIONS In inches (mm) Note: Recommended minimum clearance (behind the panel) formounting clip installation is 2.1" (53.4) H x 5.5" (140) W.C US LISTEDULR3RSDPROCESS CONTROL EQUIPMENTCAUTION: Risk of Danger.Read complete instructions prior toinstallation and operation of the unit.CAUTION: Risk of electric shock.