Sealey ECS650.V2 Manual

ELECTRONIC STARTER/CHARGER/MAINTAINER650/100A 12/24VMODEL NO: ECS650.V2Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to theseinstructions, and properly maintained, give you years of trouble free performance.IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USETHE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/ORPERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.1. SAFETYELECTRICAL SAFETY WARNING! It is the user’s responsibility to check the following:9 Check all electrical equipment and appliances to ensure that they are safe before using. Inspect power supply leads, plugs and allelectrical connections for wear and damage. Sealey recommend that an RCD (Residual Current Device) is used with all electricalproducts.1.1. Electrical safety information. It is important that the following information is read and understood:9 Ensure that the insulation on all cables and on the appliance is safe before connecting it to the power supply.9 Regularly inspect power supply cables and plugs for wear or damage and check all connections to ensure that they are secure.Important: Ensure that the voltage rating on the appliance suits the power supply to be used and that the plug is fitted with thecorrect fuse.8 DO NOT pull or carry the appliance by the power cable.8 DO NOT pull the plug from the socket by the cable.8 DO NOT use worn or damaged cables, plugs or connectors. Ensure that any faulty item is repaired or is replaced immediately by aqualified electrician.If the cable or plug is damaged during use, switch off the electricity supply and remove from use.Ensure that repairs are carried out by a qualified electrician. WARNING! Modern vehicles contain extensive electronic systems.You are required to check with the vehicle Manufacturer, for any specific instructions regarding the use of this type of equipment oneach vehicle. No liability will be accepted for damage / injury, where this product is not used in accordance with all instructions.▲ DANGER! BE AWARE, LEAD-ACID BATTERIES GENERATE EXPLOSIVE GASES DURING NORMAL BATTERY OPERATION. FOR THISREASON, IT IS VERY IMPORTANT TO READ AND FOLLOW THESE INSTRUCTIONS CAREFULLY EACH TIME YOU USE THE CHARGINGEQUIPMENT. Follow these instructions and those published by the battery manufacturer and the maker of any equipment you intend touse in the vicinity of the battery. Remember to review warning marks on all products and on engines.1.2. PERSONAL PRECAUTIONS9 When working with or near a lead-acid battery ensure there is another person within hearing range and close enough to come to youraid, should a problem arise.9 Wear safety eye protection and protective clothing. Avoid touching eyes while working near battery.9 Have fresh water and soap nearby in case battery acid contacts skin, clothing, or eyes.9 Wash immediately with soap and water if battery acid contacts skin or clothing. If acid enters eye, flush eye immediately with cool,clean running water for at least 15 minutes and seek immediate medical attention.9 Remove personal metallic items such as rings, bracelets, necklaces and watches. A lead-acid battery can produce a short-circuitcurrent high enough to weld a ring or the like to metal, which may cause severe burns.9 Ensure hands and clothing, including belts, are clear of fan blades and other moving or hot parts of the engine. Remove ties and containlong hair.8 DO NOT smoke or allow a spark or flame in the vicinity of the battery or the engine.1.3. GENERAL SAFETY INSTRUCTIONS9 Familiarise yourself with the applications, limitations and potential hazards relating to the starter/charger. Also refer to the vehiclemanufacturer’s handbook. IF IN ANY DOUBT CONSULT A QUALIFIED ELECTRICIAN.9 Ensure the starter/charger is in good order and condition before use. If in any doubt, do not use the unit and contact an electrician.9 Only use genuine parts. To use unapproved parts may be dangerous and will invalidate your warranty.Original Language Version© Jack Sealey LimitedRefer toinstructionsElectricalshockhazardWear eyeprotectionWear protectiveglovesWarningcorrosivesubstanceWarning:explosivematerialKeep awayfrom sources ofignitionUse in wellventilated areasKeep in dry areaprotect from rainECS650.V2 Issue 2 (3) 16/01/24