KENT Pearl Mineral RO Instruction Handbook For Installation, Operation And Maintenance

Contents

KENT Pearl Mineral RO Instruction Handbook For Installation, Operation And Maintenance Manual pdf 8 page image

7 8n nnn nStorage tank must be cleaned once in 2 Replace RO membrane once in a yearweeks. (Refer Cleaning the water tank) Replace UV Lamp once in a yearReplace sediment filter, activated carbon In the event of not using purifier for a longfilter & post carbon filter once in 12 months time (while going for a holiday, tour etc.),or whenever the filter change alarm make sure that you disconnect the poweractivates. It is recommended to change supply, turn off the raw water supply andFRT along with the filters drain the storage tankMaintenanceThe replacement time of consumables such as filters and membrane is dependent on thequality of raw water and water consumed.To ensure that the purifier operates at its BEST, a routine maintenance must be performed.The frequency of the maintenance will greatly depend upon the raw water quality and consumptionof purified water.Note: Filters and membrane are consumables. Their replacement time is dependent on the quality of raw water andwater consumption. They are not covered under the warranty. However, if a filter chokes within six months and amembrane within a year, it will be cleaned/repaired/replaced free of cost. Changing the filters and system inspection isavailable on call. The treatment capacity of RO membrane will reduce with time due to clogging of pores ofmembranes.“This reverse osmosis system contains a replaceable component critical to the efficiency of the system. Replacementof the reverse osmosis component should be with one of identical specifications as defined by the manufacturer, toensure the same efficiency and contaminant reduction performance.”Cleaning the Water TankThe reverse osmosis system contains a replaceable treatment component critical for the effective reductionof total dissolved solids and that product water shall be tested periodically to verify that the system isperforming properly.Replacement of spare parts are as under:--20008 SP Inline Sediment Filter 10"-20009 SP Inline Carbon Filter 8"-20001 SP RO Membrane Welded 10" Housing-20015 SP Post Carbon Filter (Blue)-20003 SP Hollow Fibre Membrane (RO)-20018 SP FRT 550Open the Upper Cover Remove the water Tank Clean it under a runningtap water and wipe drySwitch off thepower supplyRemove the TankCover/LidUse white pipe for raw water supply5. Now connect one end of white pipe to SS ball valve and other end to lowerelbow fitting connector labelled as on the left side of purifier.WATER IN,Use blue pipe for reject water6. Connect one end of blue pipe to upper elbow fitting connector labeled asand lead the other end to drain.7. Turn on the lever given on SS ball valve to initiate the water flow to purifier.8. Allow the filters to pre-soak in water for 2-3 minutes.9. Connect the power supply.10. Installation is complete.REJECT WATERTDS Adjustment*n n Turning the screw of the valve clockwise,results in a decreased mineral content.Turning the screw of the valve anti-clockwise,results in an increased mineral content.The unique TDS Control System enables customers to retain the contents of natural minerals (TDS)in purified water, as per their requirement.We recommend keeping the TDS at lowest but not below 50mg/l.n nnnnnnSwitch on the power supply Place back the storage tank and close the uppercoverAllow the storage tank to fill to the maximum level**Switch on the power supplySwitch off the power supplyPurifier is ready to useOpen the upper cover. Lift and drain the storagetank so as to remove residual dust particles presentin the pipes and storage tankStarting up the purifierThe glowing Red LED indicates power is on. The glowing Green LED indicates thepurification is on.Recommended usage of Rejected WaterAlthough the rejected water has high concentration The high concentration of salts and mineralsof salts, it is absolutely clean and free from accelerate the plant growth. Rejected water canimpurities like chlorine, dirt, sand, etc.This rejected also be used for cleaning utensils, mopping etc.water usually goes down the drain but can beused for gardening purpose.* Tested & Certified by TUV-SUD South Asia (P) Ltd.** Tested or certified flushing time - 24hrs.

/ 9

Related manuals for KENT Pearl Mineral RO