Veichi AC100-T3-1R5G Manual

Contents

Veichi AC100-T3-1R5G Manual Manual pdf 14 page image

AC100 HIGH-PERFORMANCE VC INVERTER MANUAL INSTALLATION AND WIRING113.2 Dealing Methods for Inverter after Long-term StorageIf the inverter storage time is over one year, the aluminum capacitor in the inverter must be pre-charged again andmake sure the aluminum capacitor characteristic recovered before installation. For specific method, please follow thegrads in the chart below and give more than 30 mins corresponding proportional voltage for every grad when theinverter is no-load.If the input voltage of one grad is at the critical point of contactor, fan or other equipments, please increase or reducethe corresponding input voltage for the grad to avoid any related components working under critical state.Chart 3-1: Dealing Methods for Inverter after Long-term Storage3.3 Stable Running Environment for InverterInstallation environment is very important to maximize the performance of this product and maintain long-term function,so please install the product in the environment as required in the following chart.Environment RequirementInstallation site Indoor without direct sunshineOperatingtemperature-10 ～ +40℃(hanging type)-10 ～ +45℃(cabinet type)Storage temperature -20 ～ +60℃Environment humidity <95%RH, no condensationSurroundingsPlease install the inverter in place as follows:● Place without oil mist, corrosive gases, flammable gas, dust, etc.● Place where metal dust, oil, water would not get inside the inverter (please do not installinverter on flammable material such as wood, etc).● Place without radioactive material or flammable material.● Place without poisonous gases or liquid.● Place with little salt corrosion.● Place without direct sunshine.Altitude <1000mVibration <10～20Hz:9.8m/s2<20～55Hz:5.9m/s2Installation andcooling● Inverter must be installed vertically and longitudinally, and it can’t be installed horizontally.● Please independently install high heating equipments such as braking resistor and it can’t beinstalled in the same cabinet with inverter. Installation of high heating equipments at the air-inport of the inverter is strictly prohibited.Chart 3-1:AC100 Series Inverter Running Environment Condition