Sealey BBQ10 Instructions Manual

Contents

general safety

instructions forGAS BBQ 4 Burnermodel no: BBQ10Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,and properly maintained, give you years of trouble free performance.IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USETHE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/ORPERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.1. SAfeTy1.1. GenerAl sAfetY WArnInG! The warnings, cautions and instructions in this manual cannot cover all possible conditions and situations thatmay occur. It must be understood by the operator that common sense and caution are factors which cannot be built intothis product, but must be applied by the operator. WArnInG! Hazardous fire or explosion may result if instructions are ignored.WArnInG! never use a flame to do the leak test and ensure no naked flames are nearby when doing the leakage test. WArnInG! Accessible parts may be very hot. Keep young children and pets away. WArnInG! If you smell gas: turn off the gas supply at the cylinder, extinguish all naked flames, DO nOT operate any electricalappliances, check for leaks as detailed in this manual. If odour persists, contact your Sealey dealer. WArnInG! Any modification to this appliance may be dangerous and is absolutely not permitted. WArnInG! The hood must always be open when lighting the burner.9 read the instructions carefully before assembly and retain this manual for future reference.9 use outdoors only, stand on a level surface, remember hot fat may drip out of the drip tray.9 Handle the hot barbecue with the help of oven gloves.9 the barbecue should be cleaned on a regular basis. take care not to enlarge burner ports of orifice openings when cleaning theburner or valves.9 connect the regulator and hose onto the gas cylinder, close all the valves by turning the control knobs to the “off” (fully clockwise)position.9 Always do the gas leak check before you use the barbecue and after a cylinder change. test the leakage on all the connections wheregas passes by.9 GAS LeAK CHeCK Put soapy water on all the connections where the gas reaches. open the gas cylinder valve and regulator. if bubblesare seen, tighten the connection. if bubbles are still seen, close all valves, turn off the regulator and contact your sealey dealer for help.never use the barbecue with a leak.9 the gas cylinder can only be changed by a competent person.9 use oven gloves and sturdy long handled barbecue tools when cooking on the grill.9 Be prepared if an accident or fire should occur. Know where your first aid kit and fire extinguishers are and how to use them correctly.Keep the gas supply hose away from any heated surfaces.9 ensure the appliance has completely cooled before storing.9 cylinders must be stored outdoors, upright and out of reach of children. Protect cylinder from high temperatures and replace theplastic port cap.9 this gas barbecue is designed for outside use only.8 DO nOT use in high winds.8 DO nOT move the barbecue whilst it is in operation.8 DO nOT operate if there is a gas leak.8 DO nOT attempt to disconnect any gas fitting if your barbecue is being used, including the gas hose and regulator.8 DO nOT leave unattended, from being lit to fully cooled.8 DO nOT use this barbecue in a garage or any enclosed area. Keep the surrounding area clear, at least 1.0m from any combustablematerials and 0.5m from a brick wall.8 DO nOT attempt any unauthorised interference of the main controls on this barbecue, i.e. gas taps, injectors, valve etc.8 DO nOT attempt to use charcoal in this barbecue.8 DO nOT position on a surface that may be damaged by hot fat or heat.8 DO nOT store petrol or other flammable vapours or liquids in the vicinity of this barbecue.2. InTrODuCTIOnGas barbecue with 4 stainless steel burners and piezoelectric igniter. features cast iron enamel cooking grill, built in temperaturegauge, warming rack and under grill storage cabinet. Fitted with two fixed wheels and two castors.BBQ10 | issue 2(l) 25/09/17Original Language Version© Jack sealey limitedrefer toinstructionmanualWearGlovesWarning:Hotsurface