Sealey BBQ08 Instructions Manual

1.1. GENERAL SAFETY WARNING! The warnings, cautions and instructions in this manual cannot cover all possible conditions and situations thatmay occur. It must be understood by the operator that common sense and caution are factors which cannot be built into thisproduct, but must be applied by the operator.r WARNING! Hazardous fire or explosion may result if instructions are ignored.r WARNING! Never use a flame to do the leak test and ensure no naked flames are nearby when doing the leakage test.r WARNING! Accessible parts may be very hot. Keep young children and pets away.r WARNING! If you smell gas: turn off the gas supply at the bottle, extinguish all naked flames, DO NOT operate any electricalappliances, check for leaks as detailed in this manual. If odour persists, contact your Sealey dealer.r WARNING! Any modification to this appliance may be dangerous and is absolutely not permitted.r WARNING! The hood must always be open when lighting the burner.3 Read the instructions carefully before assembly and retain this manual for future reference.3 Use outdoors only, stand on a level surface, remember hot fat may drip out of the drip tray3 Handle the hot barbecue with the help of oven gloves.3 Leak test all connections after each tank refill.3 The barbecue should be cleaned on a regular basis. Take care not to enlarge burner ports of orifice openings when cleaning theburner or valves.3 Always do the gas leak check before you use the barbecue. Test the leakage on all the connections where gas passes by.3 Connect the regulator and hose onto the gas tank and the burner, close all the valves by turning the control knobs to the "OFF" (fullyclockwise) position.3 Put soapy water on all the connections where the gas reaches. Open the gas tank valve and regulator. If bubbles are seen, tighten theconnection if bubbles are still seen, close all valves, turn off the regulator and contact your Sealey dealer for help. Never use thebarbecue with a leak.3 The gas leak check must be done when first connecting the barbecue and every time the gas bottle is changed.3 The gas bottle can only be changed by a competent person.3 The hood must always be open when lighting the burner.3 Use oven gloves and sturdy long handled barbecue tools when cooking on the grill.3 Be prepared if an accident or fire should occur. Know where your first aid kit and fire extinguishers are and how to use them correctly.3 Keep any electrical supply cord and the fuel supply hose away from any heated surfaces.3 Ensure the appliance has completely cooled before storing.3 It is essential to use the flame tamer plates (fig.3). (fits immediately above the burners and beneath the grilles)3 Cylinders must be stored outdoors, upright and out of reach of children. Protect cylinder from high temperatures and replace theplastic port cap.3 This gas barbecue is designed for outside use only.7 DO NOT use in high winds.7 DO NOT move the barbecue whilst it is in operation.7 DO NOT operate if there is a gas leak.7 DO NOT attempt to disconnect any gas fitting if your barbecue is being used, including the gas hose and regulator.7 DO NOT leave unattended, from being lit to fully cooled.7 DO NOT use this barbecue in a garage or any enclosed area. Keep the surrounding area clear, at least 1.0m from any combustablematerials and 0.5m from a brick wall.7 DO NOT attempt any unauthorised interference of the main controls on this barbecue, i.e. gas taps, injectors, valve etc.7 DO NOT attempt to use charcoal in this barbecue.7 DO NOT position on a surface that may be damaged by hot fat or heat.7 DO NOT store petrol or other flammable vapours or liquids in the vicinity of this barbecue.Original Language Version BBQ08 Issue: 1 - 05/01/15© Jack Sealey LimitedINSTRUCTIONS FOR:GAS BBQ 4 BURNERMODEL NO: BBQ08IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE THE PRODUCTCORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR PERSONAL INJURY AND WILLINVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to theseinstructions, and properly maintained, give you years of trouble free performance.1. SAFETYNOTE: This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities orlack of experience and knowledge, unless they have been given supervision or instruction concerning the use of the appliance by aperson responsible for their safety. Children should be supervised to ensure that they do not play with the appliance.Read InstructionmanualHot Surfaces Wear Protectivegloves