Sealey ASCL2 Instruction Manual

InstructIon manual for:aluminium scaffold laddermodel no: ascl2thank you for purchasing a sealey product. manufactured to a high standard this product will, if used according to these instructionsand properly maintained, give you years of trouble free performance.1. safeTY insTrucTionsIMPORTANT: Please read THese insTrucTions carefullY. noTe THe safe oPeraTional reQuiremenTs, WarninGs & cauTions.use THe ProducT correcTlY and WiTH care for THe PurPose for WHicH iT is inTended. failure To do so maY causedamaGe or Personal inJurY and Will inValidaTe THe WarranTY. Please KeeP insTrucTions safe for fuTure use.2. inTroducTion & sPecificaTion1.1 General safeTY DANGER! Take care when using and moving extended ladders in the vicinity of power cables - risk of potentially fatal electric shock. WarninG! Ensure Health and safety, local authority, and general workshop practice regulations are adhered to when using thisequipment. familiarise yourself with the application and limitations of the ladder, as well as the potential hazards. maintain the equipment in good condition. replace or repair damaged parts. use genuine parts only. unauthorised parts may be dangerous and will invalidate the warranty. Keep the work area clean, uncluttered and ensure there is adequate lighting. WarninG! use ladder on level and solid ground and either have an assistant stand on the lowest rung or otherwise anchor the base ofthe ladder to prevent slipping. WarninG! do noT use the ladder, step ladder or scaffolding on sloping ground. When viewed from the front, the top of the laddersection(s) must always be directly above the base. Place ladder at an angle of 65° to 75° - foot of ladder 1 metre from wall for each 3 metres up - for stability. Where possible, lash top of ladder to a fixture to prevent slipping. WarninG! never over-reach when on the ladder, step ladder or scaffolding. Keep children and unauthorised persons away from the working area. do noT use the ladder, step ladder or scaffolding for any purpose other than that for which they are designed. do noT use the equipment if any parts are damaged or missing as this may cause failure and/or personal injury. do noT exceed the rated capacity of the ladder, step ladder or scaffolding. do noT climb scaffolding to get onto platform. always access the platform using a separate set of steps. do noT allow children to climb the ladder, step ladder or scaffolding. do noT use the equipment when you are tired or under the influence of alcohol, drugs or intoxicating medication.2.1 introductionEn131 approved four-way scaffold ladder. two six-rung alumimium ladders can be used asextending ladder, single ladders, step ladder or complete scaffolding unit. supplied with handrail.2.2 specificationmaximum load . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 150kgExtension ladder maximum Height . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2700mmclosed length . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1670mmstep ladder Height. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1600mmPlatform length . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1320mmmaximum Platform Height . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .950mmmaximum Width (across feet). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .785mmWeight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14.7kgfig.2 fig.33. assemBlY & use3.1 Work Platform WarninG! assembling the work platform is a two-man task.3.1.1 Bolt the foot cross members to the bottom of each ladder. the feet are already attached to the cross members. refer to fig.2.3.1.2 attach the platform, at the desired height, to one ladder only.note: ensure that the hole for the hand rail is nearest to the outer face of the ladder.Original Language Version ascl2 Issue: 1 - 25/07/11fig.1

/ 3

Related manuals for Sealey 5051747622708