KENT EXCELL Mineral RO 11003 Instruction Handbook For Installation, Operation And Maintenance

Contents

KENT EXCELL Mineral RO 11003 Instruction Handbook For Installation, Operation And Maintenance Manual pdf 6 page image

8Note: Filters and membrane are consumables. Their replacement time is dependent on the quality ofraw water and water consumption. They are not covered under the warranty. However, if a filterchokes within six months and a membrane within a year, it will be cleaned/repaired/replaced free ofcost. Changing the filters and system inspection is available on call. The purification capacity of ROmembrane will reduce with time due to clogging of pores of membranes.To ensure that the purifier operates at its Replace the RO membrane once in a yearoptimum level, a routine maintenance must be Replace the UV Lamp once in a yearperformed. The frequency of the maintenanceIf you are not going to use the purifier for awill greatly depend upon the raw water quality long time (in case you are on a holiday, tourand consumption of purified water. or out of home), make sure that youdisconnect the power supply, turn off the rawReplace sediment, activated carbon blockwater supply and drain the storage tankand micronic filter when the filter changealarm is audible OR after every 12 months. Itis recommended to change the FRT when thefilters are replacednnnnMaintenancen nnnnnSwitch on the power supply Drain off the storage tank by opening thefaucet to remove any dust particles from thepipe and storage tankWait approximately for half an hour so thatthe storage tank fully fills up** Close the faucet & switch on the power supplyThe purifier is ready to useSwitch off the power supplyStarting Up the PurifierTDS Adjustment*Although the rejected water has high required, can be used for gardening purposes.concentration of salts, it is absolutely clean and It has high concentration of salts and mineralsfree of impurities like chlorine, dirt, sand, etc. which accelerates plant growth. Rejected waterwhich are present in raw water. This rejected can also be used for cleaning purposes, i.e.water usually goes down the drain but if cleaning utensils, mopping, etc.Recommended Usage of Rejected WaterFigure 273 Way ConnectorSS Ball Valve90 DegreeBall Valve“This reverse osmosis system contains a replaceable component critical to the efficiency of thesystem. Replacement of the reverse osmosis component should be with one of identicalspecifications as defined by the manufacturer, to ensure the same efficiency and contaminantreduction performance.”The reverse osmosis system contains a replaceable treatment component critical for the effectivereduction of total dissolved solids and that product water shall be tested periodically to verify that thesystem is performing properly.Replacement of spare parts are as under:-* Tested & Certified by TUV-SUD South Asia (P) Ltd.** Tested or certified flushing time - 24hrs.-20011 SP Sediment Filter 10"-20012 SP Activated Carbon Filter 10"-20001 SP RO Membrane Welded 10" Housing-20015 SP Post Carbon Filter (Blue)-20003 SP Hollow Fibre Membrane (RO)-20018 SP FRT 550The unique TDS Controller enables customers to retain the contents of natural minerals in purifiedwater as per their requirement.n Turning the screw of the valve clockwiseresults in a decreased mineral contentn Turning the screw of the valve anticlockwise results in an increasedmineral content

/ 7

Related manuals for KENT EXCELL Mineral RO 11003