OneStart

Menu

HeatRite VM-80 Installation, Operation & Service Manual

Page 1 preview
Page 2 preview
Page 3 preview
Page 4 preview
Page 5 preview
Page 6 preview
Page 7 preview
Page 8 preview
Page 9 preview
Page 10 preview
Page 11 preview
Page 12 preview
Page 13 preview
Page 14 preview
Page 15 preview
Page 16 preview
Page 17 preview
Page 18 preview
Page 19 preview
Page 20 preview
Page 21 preview
Page 22 preview
Page 23 preview
Page 24 preview
Page 25 preview
Page 26 preview
Page 27 preview
Page 28 preview
Page 29 preview
Page 30 preview
Page 31 preview
Page 32 preview
Page 33 preview
Page 34 preview
Page 35 preview
Page 36 preview
Page 37 preview
Page 38 preview
Page 39 preview
Page 40 preview
Page 41 preview
Page 42 preview
Page 43 preview
Page 44 preview
Page 45 preview
Page 46 preview
Page 47 preview
Page 48 preview
Page 49 preview
Page 50 preview
Page 51 preview
Page 52 preview
Page 53 preview
Page 54 preview
Page 55 preview
Page 56 preview
Page 57 preview
Page 58 preview
Page 59 preview
Page 60 preview
Page 61 preview
Page 62 preview
Page 63 preview
Page 64 preview
Page 65 preview
Page 66 preview
Page 67 preview
Page 68 preview
Page 69 preview
Page 70 preview
Page 71 preview
Page 72 preview
Page 73 preview
Page 74 preview
Page 75 preview
Page 76 preview
Page 77 preview
Page 78 preview
Page 79 preview
Page 80 preview
Contents
  1. Table Of Contents
  2. Table Of Contents
  3. SECTION 1: Heater Safety
  4. figure 1: top and bottom panel label placement
  5. figure 2: side and back panel label placement
  6. SECTION 2: Installer Responsibility
  7. National Standards and Applicable Codes
  8. SECTION 3: Clearances to Combustibles
  9. SECTION 4: National Standards and Applicable Codes
  10. SECTION 5: Major Components
  11. Standard Parts List
  12. SECTION 6: Heater Installation
  13. typical suspension details
  14. figure 12: linear heater assembly overview
  15. figure 13: linear heater layout overview
  16. Burner Tube Installation
  17. Coupling and Tube Assembly
  18. Turbulator Installation
  19. Reflector Installation
  20. Burner Installation
  21. SECTION 7: Optional Heater Accessories
  22. figure 14: u-tube heater assembly overview
  23. figure 15: u-tube heater layout overview
  24. Elbow Package Configuration
  25. figure 16: reflector joint detail
  26. Reflector Side Extension
  27. Lower Clearance Shield Installation
  28. Protective Grille Installation
  29. SECTION 8: Venting
  30. Horizontal Venting
  31. Vertical Ventilation 4" (10 cm) Pipe
  32. Common Vertical Venting
  33. Outside Combustion Air Supply
  34. SECTION 9: Gas Piping
  35. figure 18: gas connection with flexible gas hose
  36. SECTION 10: Wiring
  37. figure 20: low voltage brooder control wiring
  38. Standard Heater Configuration
  39. Central and Satellite Heaters (Zoning Capability)
  40. Communication Wiring within a Zone of Heaters
  41. Heat Demand Control Wiring
  42. figure 26: analog control signal wiring diagram
  43. figure 27: potentiometer control wiring diagram
  44. Internal Wiring
  45. Ladder Diagram
  46. Low Voltage Control Wiring Installation
  47. SECTION 11: Operation and Maintenance
  48. SECTION 12: Troubleshooting
  49. Control LED
  50. Troubleshooting Flow Chart
  51. Manifold Gas Pressure Measurement
  52. Pneumatic Connections
  53. SECTION 13: Replacement Parts
  54. SECTION 14: General Specifications
HeatRite VM-80 Installation, Operation & Service Manual Manual pdf 36 page image
VM-S ERIES I NSTALLATION, OPERATION AND S ERVICE M ANUAL30 of 717.6 Protective Grille InstallationStep 7.6.1 Silicone Cap InstallationStep 7.6.2 Grille End Cap InstallationStep 7.6.3 Grille Installation #  .'H ## Description Part NumberGrille Section 08050001Grille End Cap 08050002Silicone Cap 91915951-6P  728:  3 :; ; A BC D         
/ 80
This manual is suitable for:
VM-115VM-150VM-200VM-80
Product
Menu
Learn More
Menu
Legal
Menu
Copyright © 2024 OneStart. All Rights Reserved