Menu
HeatRite VM-80 Installation, Operation & Service Manual
                                                                                | |
Contents
| 
© 2012 Roberts-Gordon LLCAll rights reserved. No part of this work covered by the copyrights herein may be reproducedor copied in any form or by any means - graphic, electronic, or mechanical, includingphotocopying, recording, taping or information storage and retrieval systems - without thewritten permission of Roberts-Gordon LLC.TABLE OF CONTENTSSECTION 1: Heater Safety...................................................... 11.1 Manpower Requirements ............................................. 11.2 Safety Labels and Their Placement ............................. 11.3 California Proposition 65 .............................................. 1SECTION 2: Installer Responsibility ..................................... 42.1 Wall Tag ....................................................................... 42.2 Brooder Wall Tag ......................................................... 42.3 Corrosive Chemicals.................................................... 42.4 National Standards and Applicable Codes .................. 5SECTION 3: Clearances to Combustibles............................. 63.1 Required Clearances to Combustibles......................... 6SECTION 4: National Standards and Applicable Codes ..... 94.1 Gas Codes................................................................... 94.2 Aircraft Hangars ........................................................... 94.3 Public Garages ............................................................ 94.4 Electrical ...................................................................... 94.5 Venting......................................................................... 94.6 High Altitude ................................................................ 9SECTION 5: Major Components .......................................... 105.1 Standard Parts List .................................................... 11SECTION 6: Heater Installation............................................ 126.1 Burner Tube Installation ............................................ 166.2 Tube Clamp Package Installation .............................. 166.3 Coupling and Tube Assembly.................................... 176.4 Turbulator Installation ................................................ 186.5 Reflector Installation .................................................. 196.6 Burner Installation...................................................... 21SECTION 7: Optional Heater Accessories .......................... 227.1 U-Tube Configuration.................................................. 227.2 Elbow Package Configuration..................................... 257.3 Reflector Side Extension ............................................ 277.4 Lower Clearance Shield Installation ........................... 287.5 Two-Foot Decorative Grille Installation ....................... 287.6 Protective Grille Installation ........................................ 30SECTION 8: Venting.............................................................. 318.1 Venting....................................................................... 318.2 Unvented Operation................................................... 318.3 Horizontal Venting...................................................... 328.4 Vertical Venting .......................................................... 328.5 Unvented Operation Tube Termination ...................... 328.6 Length Requirements ................................................ 328.7 Horizontal Ventilation 4" (10 cm) Pipe........................ 328.8 Vertical Ventilation 4" (10 cm) Pipe ............................ 338.9 Common Side Wall Venting ....................................... 338.10 Common Vertical Venting ........................................ 348.11 Outside Combustion Air Supply ............................... 35SECTION 9: Gas Piping........................................................ 37SECTION 10: Wiring.............................................................. 3910.1 Heater Wiring for use with Brooder Contoller........... 3910.2 Standard Heater Configuration ................................ 4110.3 Central and Satellite Heaters (Zoning Capability) .... 4210.4 Communication Wiring within a Zone of Heaters ..... 4410.4 Communication Wiring within a Zone of Heaters(continued) ...................................................................... 4510.5 Heat Demand Control Wiring ................................... 4610.6 Internal Wiring.......................................................... 5410.7 Ladder Diagram ....................................................... 5510.8 Electrical Connection to the Burner ......................... 5510.9 Low Voltage Control Wiring Installation.................... 56SECTION 11: Operation and Maintenance.......................... 5711.1 Sequence of Operation ............................................ 5711.2 To Shut Off Heater.................................................... 5711.3 To Start Heater ......................................................... 5711.4 Pre-Season Maintenance and Annual Inspection..... 57SECTION 12: Troubleshooting............................................. 6012.1 Control LED ............................................................. 6112.2 General LED Codes ................................................ 6112.3 Troubleshooting Flow Chart ..................................... 6312.4 Manifold Gas Pressure Measurement...................... 6512.5 Pneumatic Connections........................................... 66SECTION 13: Replacement Parts ........................................ 67SECTION 14: General Specifications .................................. 7014.1 Material Specifications............................................. 7014.2 Heater Specifications............................................... 7014.3 Suspension Specifications....................................... 7014.4 Controls Specifications ............................................ 70Printed in U.S.A.There are references in this manual to various trademarks. All trademarks mentioned herein, whether registered or not, are theproperty of their respective owners. Roberts-Gordon LLC is not sponsored by or affiliated with any of the trademark or regis-tered trademark owners, and make no representations about them, their owners, their products or services. Roberts-GordonLLC is not sponsored by or affiliated with BACnet® or LonWorks®. |
Product
Learn More
Legal
Copyright © 2024 OneStart. All Rights Reserved