Cal Flame BBQ845P Owner's Manual

Also see for BBQ843P: Owner's manual

Contents

Cal Flame BBQ845P Owner's Manual Manual pdf 10 page image

Page 8 2008 Barbecue Grill and Cart Owner’s ManualLTR20081050, Rev. AUsing Your GrillEach time you light the grill, check the following:Inspect the hose before using the grill. If there is•excessive abrasion or wear, or if the hose is cut,it must be replaced prior to using the grill. If youneed a replacement hose, contact your Cal Flamedealer.Ensure the area around the barbecue is clear of•flammable substances such as gasoline, yard de-bris, wood, etc.Ensure there is no blockage of the airflow through•the vent space located below the face of the unit.When using propane gas:•Keep the special ventilation openings in•the enclosure free and clear of debrisIf connected to a propane cylinder, careful-•ly inspect the rubber hose attached to theregulator before each useEnsure the propane cylinder, regulator, and•rubber hose are installed in a location notsubject to heating above 125º F (51º C)Ensure the burner flames burn evenly along both•sides of each burner with a steady flame (mostlyblue with yellow tipping). If burner flames are notnormal, check the orifice and burner for insects orinsect nests.Ensure the in-line gas valve or gas cylinder valve is•always shut OFF when the barbecue is not in use.Electronically Lighting the GrillOpen the hood.1.Keep your face as far away from the burners as pos-2.sible.Rapidly rotate the burner knob counter clockwise3.past the light position to HIGH. You will hear a loudclick as the electronic lighter produces a spark.Listen for the sound of the gas igniting. If the burner4.does not light on the first try, repeat immediately.If the burner does not light after three attempts, turn5.the control knobs to the OFF position. Wait five min-utes until the gas clears before attempting to light itagain.Repeat the procedure or try the manual lighting pro-6.cedure below.Upon successful lighting, repeat the process on the7.other burners you wish to light.To shut off the burners, rotate the knob and turn to8.OFF. It is normal to hear a popping sound when theburners are turned off.Lighting the GrillManually Lighting the GrillWARNING: Do not use standard matches or cigarettelighters to perform match lighting procedures. Seriousburns can occur and lighters can explode.Open the hood.1.If you have just attempted to light the burner, allow2.five minutes for any accumulated gas to dissipate.Slide out the drip tray from the grill.3.Keep your face as far away from the burners as pos-4.sible.Light and insert a long stem match, holding it near5.the burner ports.Push in and turn the control knob just past the LIGHT6.position to HIGH.Listen for the sound of the gas igniting. If the burner7.does not light after five seconds, turn the controlknobs to the OFF position. Wait five minutes untilthe gas clears before attempting to light it again.If the burner does not light after several attempts see8.Troubleshooting Guide in the back of this manual.