Toro 31230 Operator's Manual

Also see for Groundsmaster 360: Operator's manual Operator's manual Operator's manual Operator's manual Operator's manual

• Stop the blades from rotating before crossing surfacesother than grass.• When using any attachments, never direct discharge ofmaterial toward bystanders nor allow anyone near themachine while in operation.• Never operate the machine with damaged guards, shields,or without safety protective devices in place.• Do not change the engine governor settings or overspeedthe engine. Operating the engine at excessive speed mayincrease the hazard of personal injury.• Before leaving the operator's position:– disengage the power take-off and lower theattachments;– set the parking brake;– stop the engine and remove the key.• Disengage drive to attachments, stop the engine, andremove the ignition key:– before clearing blockages or unclogging chute;– before checking, cleaning or working on the machine;– after striking a foreign object. Inspect the machinefor damage and make repairs before restarting andoperating the equipment;– if the machine starts to vibrate abnormally (checkimmediately).• Do not operate the machine under the influence ofalcohol or drugs.• Lightning can cause severe injury or death. If lightningis seen or thunder is heard in the area, do not operatethe machine; seek shelter.• Disengage drive to attachments when transporting or notin use.• Stop the engine and disengage drive to attachment beforerefueling.Rollover Protection System (ROPS) -Use and Maintenance• The ROPS is an integral and effective safety device. Keepa folding ROPS in the raised and locked position and usethe seat belt when operating the machine.• Lower a folding ROPS temporarily only when absolutelynecessary. Do not wear the seat belt when folded down.• Be aware there is no rollover protection when a foldedROPS is in the down position.• Be certain that the seat belt can be released quickly inthe event of an emergency.• Check the area to be mowed and never fold down afolding ROPS in areas where there are slopes, drop offsor water.• Check carefully for overhead clearances (i.e. branches,doorways, electrical wires) before driving under anyobjects and do not contact them.• Keep the ROPS in safe operating condition byperiodically thoroughly inspecting for damage andkeeping all mounting fasteners tight.• Replace a damaged ROPS. Do not repair or revise.• Do not remove the ROPS.• Any alterations to a ROPS must be approved by themanufacturer.Maintenance and Storage• Keep all nuts, bolts and screws tight to be sure theequipment is in safe working condition.• Never store the equipment with fuel in the tank inside abuilding where fumes may reach an open flame or spark.• Allow the engine to cool before storing in any enclosure.• To reduce the fire hazard, keep the engine,silencer/muffler, battery compartment and fuel storagearea free of grass, leaves, or excessive grease.• Replace worn or damaged parts for safety.• If the fuel tank has to be drained, do this outdoors.• On multi-bladed machines, take care as manually rotatingone blade can cause other blades to rotate.• When machine is to be parked, stored or left unattended,lower the mower deck.Hauling• Use care when loading or unloading the machine into atrailer or truck.• Use full width ramps for loading machine into trailer ortruck.• Tie the machine down securely using straps, chains, cable,or ropes. Both front and rear straps should be directeddown and outward from the machineToro Riding Mower SafetyThe following list contains safety information specific to Toroproducts or other safety information that you must know thatis not included in the standard.• Engine exhaust contains carbon monoxide, which is anodorless, deadly poison that can kill you. Do not runengine indoors or in an enclosed area.• Keep hands, feet, hair and loose clothing away fromattachment discharge area, underside of mower and anymoving parts while engine is running.• Do not touch equipment or attachment parts which maybe hot from operation. Allow to cool before attemptingto maintain, adjust, or service.• Battery acid is poisonous and can cause burns. Avoidcontact with skin, eyes and clothing. Protect your face,eyes, and clothing when working with a battery.5