Sealey ROADSTART RS131.V6 Instructions Manual

ROADSTART® EMERGENCY POWER PACK12V 900 PEAK AMPSMODEL NO: RS131.V6IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE THE PRODUCTCORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR PERSONAL INJURY AND WILLINVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to theseinstructions and maintained properly, give you years of trouble free performance.RS131.V6 Issue: 1 - 11/10/18Original Language Version© Jack Sealey Limited1. SAFETYIMPORTANT WARRANTY INFORMATION: KEEP YOUR ROADSTART HEALTHY Read and understand the general safety and operating instructions before use. The following information is intended to help youkeep the product in top working order.NOTE: – The battery in this unit is a consumable item and its ability to accept charge will reduce over time. We will provide warrantyagainst mechanical and electrical defect for a period of one year - this does not cover fair wear and tear.If the battery is not charged properly before first use, or regularly conditioned, its capacity will diminish. Under these circumstances wewill not replace the battery even if it is less than one year old. You can help prolong the life of the battery by following a few simple guidelines. Plug in your new Roadstart to the mains transformer and make an INITIAL charge lasting 38 hours. Ensure the unit is fully charged before storage. DO NOT leave the Roadstart for longer than 2 months without putting it on charge. DO NOT attempt to start a vehicle when the Roadstart battery level lights show red. DO NOT drop or roughly handle the Roadstart – this will break or disjoin the battery terminals rendering the battery useless and thewarranty void. DO NOT use any other charger, other than the one supplied, to recharge the battery. DO NOT obstruct the ventilation grilles and protect against water ingress - The RoadStart units are fitted with ventilation grilles to helpdisperse any gases produced during the charging procedure.IMPORTANT: To reduce the risk of a battery explosion, follow these instructions and those published by the battery manufacturerand the manufacturer of any equipment you intend to use in the vicinity of the battery. Remember to review warning marks on allproducts and on engines. Modern vehicles contain extensive electronic systems. Check with the vehicle manufacturer forany specific instructions regarding the use of this type of equi pment on each vehicle. No liability will be accepted for damage/injurywhere this product is not used in accordance with all instructions.1.1. PERSONAL PRECAUTIONS Ensure there is another person within hearing range, or close enough to come to your aid should a problem arise, when workingnear a lead-acid battery. Have fresh water and soap nearby in case battery acid contacts skin, clothing or eyes. Wear safety eye protection and protective clothing. Avoid touching eyes while working with a battery. Wash immediately with soap and water if battery acid contacts skin or clothing. If acid enters eye, flush eye immediately with cool,clean running water for at least 15 minutes and seek immediate medical attention. Remove personal metallic items such as rings, bracelets, necklaces and watches. A lead-acid battery can produce a short-circuitcurrent high enough to weld a ring or the like to metal, which may cause severe burns.1.2. IMPORTANT SAFETY INSTRUCTIONS Familiarise yourself with the applications, limitations and potential hazards of the RoadStart. Keep the unit in good working order and condition. Replace damaged parts immediately. Use only recommended parts. To use unapproved parts may be dangerous and will invalidate your warranty. The RoadStart must only be opened and checked by qualified servi ce personnel. DO NOT disassemble the unit for any reason. Keep children and unauthorised persons away from the work area. Keep work area clean and tidy and free from unrelated materials. Ensure that there is adequate lighting. If the RoadStart receives a sharp knock or blow, it must be checked by a qualified service agent before being used. When not in use re-charge every two months. DO NOT smoke or allow a spark or flame in the vicinity of the battery or engine. DO NOT drop any metal item onto the battery as it may spark or short circuit the battery, which could cause an explosion. DO NOT use RoadStart to recharge dry cell batteries that are commonly used with home appliances. These batteries may explodeand cause personal injury and damage to property. DO NOT charge or boost a frozen battery. DO NOT use attachments other than those recommended. To do so may risk damage to the unit and other equipment and possiblepersonal injury. DO NOT pull or carry the unit by its cables and DO NOT pull the negative and positive clamps from the battery terminals. DO NOT operate in vicinity of flammable liquids or gases. DO NOT recharge the unit with plugs, cables or attachments that are damaged. Replace such items immediately.Refer toInstructionManualWarning:ExplosivematerialWarning:CorrosivesubstanceWear eyeprotectionWearprotectiveglovesElectricalshock hazardKeep in dryarea. Protectfrom rainUse in wellventilatedareasKeep awayfrom sourcesof ignition

/ 5

Related manuals for Sealey ROADSTART RS131.V6