Sealey EWP050 Instructions Manual

Refer toInstructionsWear eyeprotectionWear earprotectionWear protectivegloves1. SAFETY INSTRUCTIONSINSTRUCTIONS:PETROL WATER PUMP 50mm 5.5hpM O D E L No: EWP0501.1 GENERAL SAFETY WARNING! Stop the engine and disconnect the inlet and outletpipes before performing any maintenance. WARNING! Do not operate the pump if damaged. Replace orrepair using recommended parts only. Unauthorised parts maybe dangerous and will invalidate your warranty. Use authorisedService agent only. Keep the pump in good condition. Regular maintenance willgive the best and safest performance. WARNING! DO NOT operate the pump without any waterpassing through it. To do so will damage the machine. WARNING! DO NOT operate the pump without the priming itfirst. To do so will damage the machine. WARNING! Use the pump on a flat, level surface, in ahorizontal position. Failure to do so will invalidate your warranty. Wear safety goggles, adequate protective clothing andanti-slip rubber soled footwear. Keep all persons and animals at a safe distance from theworking pump DO NOT allow children or untrained persons to operate the pump. DO NOT use the pump if the water inlet pipe is damaged.Also check that the hose is laid out straight and safely. DO NOT try to move the pump by pulling on the inlet or outletpipes. Use the machine frame. DO NOT direct the pump output towards yourself, otherpersons or animals, electrical equipment or the pump itself. DO NOT use the pump if you are tired or under the influence ofalcohol, drugs or intoxicating medication. When not in use, drain any water from the pump. Clean anddry the pump and store in a safe, dry, childproof area. DO NOT allow the pump to become frozen.1.2 ENGINE SAFETY WARNING! Check the engine oil level before each startup.Only use an SAE10W30 oil and never operate the enginewith insuffient oil. WARNING! DO NOT touch spark plug or plug lead with wet (ordry) hands whilst the engine is running - severe, potentiallyfatal, electric shock may result. For safety instructions relative to the maintenance and use ofthe petrol engine refer to the engine instruction manual. DO NOT check ignition system by removing the spark plug orspark plug lead. Use specific tester or contact service agent. DO NOT operate the pump in an enclosed area as the motorexhaust fumes are a health hazard. DO NOT use the pump with flammable, toxic or corrosive liquids. DO NOT leave the pump unattended whilst operating, and DONOT remove the fuel cap whilst the engine is running. DO NOT refuel the engine whilst it is running. Stop the engineand allow it to cool for two minutes before attempting to refuel. DO NOT refuel in a closed or poorly ventilated environment asthere is a danger of explosion or fire. Refuel out doors. DO NOT smoke or place the pump near any naked flameswhilst re-fuelling. DO NOT operate pump if there is a fuel leak. Move the unit andavoid any combustion until the leak has been fixed and themachine is dry. DO NOT start the engine if there are any flammable materialsnear the exhaust system or in the path of the exhaust gases.2. INTRODUCTION & SPECIFICATION3. FITTINGS & ACCESSORIESModel No: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . EWP050Motor Power: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5.5hpMotor Type: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-stroke/UnleadedInlet Ø: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .50mmOutlet Ø: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .50mmMaximum Output: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .600ltr/minMaximum Head: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26mtrMaximum Suction Head: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8mtrMaximum Tank Capacity: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3.6ltrNoise Rating LwA: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99dBDry Weight: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27kgDimensions: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .477 x 385 x 417Lay Flat Hose: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . LFH1050Solid Wall Hose: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .EWP050SWIntroduction:Economically designed petrol powered water pump with recoilstarting. Suitable for on site applications where mains power supply isnot available. Featuring 50mm inlet/outlet with 26mtr pumping headoffering a high flow rate up to 600ltr/min of water. Fitted on to framewith high density rubber shock absorbers, frame also aids withprotection from accidental damage.Fittings:1. Air filter cover2. Air filter3. Inlet/Outlet connector x 24. Connector locking ring x 25. Sealing washer x 26. Wire pipe clamp x 37. Petrol tank cap8. Filter basket9. Filter basket cover10. Petrol tank filter11. Spark plug spanner bar12. Spark plug spannerfig.1IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE THE PRODUCTCORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR PERSONAL INJURY AND WILLINVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to theseinstructions and maintained properly, give you years of trouble free performance. DO NOT block the engine ventilation grilles. Ensure engine fuel is stored in an approved container. For long term storage ensure the fuel is drained and that thepump is adequately protected against frost. DO NOT operate the engine with either the silencer or air filterremoved. DO NOT touch the engine during or after use. To avoid burnsallow it to cool before handling.EWP050 Issue :4(L) -10/07/17© Jack Sealey Limited Original Language Version

/ 5

Related manuals for Sealey EWP050