Sealey CP108VCPBO Quick Start Manual

Also see for CP108VCPBO: Quick start guide

10.8V Ø75MM CORDLESS POLISHER - BODY ONLYMODEL NO: CP108VCPBOThank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,and properly maintained, give you years of trouble free performance.IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USETHE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/ORPERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.1. SAFETY9 Disconnect the polisher from the battery unit before changing accessories, servicing or performing any maintenance.9 Maintain the polisher and battery in good condition. Check moving parts alignment on a regular basis.9 Replace or repair damaged parts. Use an authorised service agent and recommended parts only. Unauthorised parts may bedangerous and will invalidate the warranty.9 Ensure the polisher is switched off before installing the battery pack.9 Keep the polisher and charger clean for best and safest performance.9 Remove ill fitting clothing. Remove ties, watches, rings and other loose jewellery and contain long hair.9 Evaluate your working area before using the polisher e.g. ceilings, floors and enclosures may contain electrical items or water piping.9 Ensure battery pack is correctly inserted into the polisher handle and latched in place before attempting to switch on polisher.9 Secure loose work pieces with a clamp, vice or other adequate holding device.9 Avoid unintentional starting.9 Wear approved safety eye protection (standard spectacles are not adequate).9 Maintain correct balance and footing. Ensure the floor is not slippery and wear non-skid shoes.9 Keep children and unauthorised persons away from the working area.9 Store polisher and charger in a safe, dry, childproof area where the temperature will not exceed 104°F (40°C).8 DO NOT use the polisher where there are flammable liquids, solids or gases, such as paint solvents, etc.8 DO NOT allow children to operate the polisher.8 DO NOT operate the polisher if any parts are missing as this may cause failure and/or personal injury.8 DO NOT hold unsecured work piece in your hand.8 DO NOT leave the polisher operating unattended.8 DO NOT carry the polisher with your finger on the power switch.8 DO NOT use the polisher for a task it is not designed to perform.8 DO NOT operate the polisher when you are tired or under the influence of alcohol, drugs or intoxicating medication.8 DO NOT get the polisher or battery wet or use in damp or wet locations.2. INTRODUCTIONCompact, lightweight cordless polisher - body only. Comfortable housing with soft grip to help reduce vibration. Variable speed control trigger makesthis polisher very easy-to-use. Supplied with side handle and polishing pad. Requires compatible 10.8V 2Ah or 4Ah battery and mains charger, soldseparately.3. SPECIFICATIONModel No. .......................................................CP108VCPBOBattery .................. 10.8V 2Ah-4Ah Lithium-ion (not included)Consumable parts (not included)..........................................................CP108VBP 2Ah Battery........................................................CP108VBP4 4Ah BatteryFree speed ..........................................0-2600rpm/0-7800rpmNoise power/pressure .......................................... 91/80dB(A)Vibration/rating .............................................. 4.7m/s²/1.5m/s²Pad size .................................................................... Ø75mmReplacement parts .....................CP108VMC - Mains chargerThread size ....................................................................... M64. OPERATION4.1. Fit battery.4.2. BATTERY CHARGE STATUS TEST4.2.1. Press trigger, all LEDs lit: battery charged, one LED lit: battery needscharging.4.3. In order to maintain battery efficiency:8 DO NOT fully discharge. After every use fully charge the battery, charge every 4 months even if tool is not used.Original Language Version© Jack Sealey LimitedRefer toinstructionmanualWear protectivegloves Wear eyeprotection Wear facemask Wear earprotectionfig.1CP108VCPBO Issue 2 (3) 06/06/22

/ 2

Related manuals for Sealey CP108VCPBO