Sealey CP108VCIWBO Instructions Manual

10.8V 3/8”SQ DRIVE CORDLESS IMPACTWRENCH - BODY ONLYMODEL NO: CP108VCIWBOThank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to theseinstructions, and properly maintained, give you years of trouble free performance.IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USETHE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/ORPERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.1. SAFETY9 Maintain the Impact Wrench and battery in good condition. Check moving parts alignment on a regular basis.9 Replace or repair damaged parts. Use an authorised service agent and recommended parts only. Unauthorised parts may bedangerous and will invalidate the warranty.9 Ensure the Impact Wrench is switched off before installing the battery pack.9 Keep the Impact Wrench and charger clean for best and safest performance.9 Remove ill fitting clothing. Remove ties, watches, rings and other loose jewellery and contain long hair.9 Evaluate your working area before using the Impact Wrench; e.g. ceilings, floors and enclosures may contain electrical items orwater piping9 Ensure battery pack is correctly inserted into the Impact Wrench handle and latched in place before attempting to switch on ImpactWrench.9 Secure loose work pieces with a clamp, vice or other adequate holding device.9 Avoid unintentional starting.9 Wear approved safety eye protection (standard spectacles are not adequate).9 Maintain correct balance and footing. Ensure the floor is not slippery and wear non-skid shoes.9 Be aware that this Impact Wrench does not need to be plugged into the mains power.9 Keep direction switch in the locked position until the Impact Wrench is required for use.9 Keep children and unauthorised persons away from the working area.8 DO NOT use the Impact Wrench where there are flammable liquids, solids or gases, such as paint solvents, etc.8 DO NOT allow children to operate the Impact Wrench.8 DO NOT operate the Impact Wrench if any parts are missing as this may cause failure and/or personal injury.8 DO NOT hold unsecured work piece in your hand.8 DO NOT leave the Impact Wrench operating unattended.8 DO NOT carry the Impact Wrench with your finger on the power switch. Keep direction switch in the locked position.8 DO NOT use the Impact Wrench for a task it is not designed to perform.8 DO NOT operate the Impact Wrench when you are tired or under the influence of alcohol, drugs or intoxicating medication.8 DO NOT get the Impact Wrench or battery charger wet or use in damp or wet locations.2. INTRODUCTIONCompact, lightweight cordless impact wrench - body only. Robust housing with soft grip to reduce vibration. Integrated LED battery levelindicator and LED work light. Requires compatible 10.8V 2Ah or 4Ah battery and mains charger, sold separately.3. SPECIFICATIONModel No.. ....................................................CP108VCIWBOBattery ................ 10.8V 2Ah - 4Ah Lithium-ion (not included)Consumable parts (not included)..........................................................CP108VBP 2Ah Battery........................................................CP108VBP4 4Ah BatteryDrive ........................................................................... 3/8”SqMax. torque .................................................... 120Nm(88lb.ft)Noise power/pressure .......................................... 84/73dB(A)No-load speed.......................................................0-2200rpmVibrating rating ...................................... 0.571 m/s² / 1.5 m/s²Replacement parts .....................CP108VMC - mains charger4. OPERATION4.1. Fit battery.4.2. BATTERY CHARGE STATUS TEST4.2.1. Press trigger, all LEDs lit: battery charged, one LED lit: battery needscharging.CP108VCIWBO Issue 1 02/02/21Original Language Version© Jack Sealey LimitedRefer toinstructionsWear eyeprotectionWear protectiveglovesWear earprotectionWear a maskWorklightTriggerShown withbattery fitted(not supplied)DirectionselectorChargestateLEDs

/ 3

Related manuals for Sealey CP108VCIWBO