Sealey AK4561D.V2 Quick Start Manual

AIR OPERATED OIL DISPENSING SYSTEMMODEL NO: AK4561D.V2Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to theseinstructions, and properly maintained, give you years of trouble free performance.IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USETHE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/ORPERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.1. SAFETY WARNING! Ensure health & safety, local authority, and general workshop practice regulations are strictly adhered to when using thisequipment.9 Familiarise yourself with product application and limitations, as well as the specific potential hazards peculiar to this product.9 Maintain the pump station in good condition (use an authorised service agent).9 Replace or repair damaged parts. Use genuine parts only. Non authorised parts will invalidate the warranty.9 Use only to pump lubricants up to SAE 150 viscosity.9 Ensure safety eye protection, oil resistant gloves and protective clothing are worn when using this product.9 Keep the work area clean, uncluttered and ensure there is adequate lighting.9 Maintain correct balance and footing. Ensure the floor is not slippery and wear non slip shoes.9 Keep children and unauthorised persons away from the working area.9 After use, drain any fluids from the equipment before storage.9 Dispose of waste liquids in accordance with local authority regulations.9 Disconnect air pressure from equipment when not in use.8 DO NOT exceed the maximum air pressure of 115psi.8 DO NOT point the nozzle at people or animals.8 DO NOT use the equipment near open flames.8 DO NOT smoke whilst using this equipment.8 DO NOT use to extract corrosive fluids.8 DO NOT dismantle, tamper with or adapt the pump for any purpose other than for which it is designed.8 DO NOT use the unit if it has been dropped or mishandled, check the unit to ensure there is no damage.8 DO NOT leave the trolley on a slope, or traverse slopes, which may cause the unit to topple.9 The unit must be stored on a level surface.9 Keep the pump clean and store in a safe dry, childproof location. WARNING! DO NOT allow uncontrolled discharge of fluids thuspolluting the environment. All liquids must be disposed of accordingto local authority regulations.2. INTRODUCTIONMobile oil dispensing unit with air operated 3:1 double acting pump for barrelor tanks with 2”BSP fittings. Pump is supplied with air management systemand connected to a 940mm rigid suction probe with non-return valve. Featurestrolley, 4m hose and digital oil meter (Model No. AK4565D supplied). Suitablefor use with 205L drums and with engine, hydraulic, synthetic, gear andtransmission oils up to SAE150.3. SPECIFICATIONModel No: ...............................................................AK4561DMaximum Air Pressure: ................................................115psiMaximum Flow Rate: ................................................ 12L/minMaximum Output Pressure: ........................................ 350psiMaximum Trolley Capacity: .......................................... 220kgMaximum Viscosity: .................................................. SAE150Outlet Size: ...............................................................1/2”BSPPump Ratio: ...................................................................... 3:1Recommended Air Pressure: ........................................ 70psiDigital Hose End MeterModel: ..................................................................... AK4565DAccuracy: ..................................................................+/- 0.5%Inlet: .......................................................................... 1/2”BSPBattery: ......................................... Lithium CR2 3V 1400mAHAK4561D.V2 Issue 1 25/05/21Original Language Version© Jack Sealey LimitedRefer toinstructionsWear eyeprotectionWear protectiveglovesWear safetyfootwearWear protectiveclothingfig.1

/ 4

Related manuals for Sealey AK4561D.V2