Razor Pocket Mod Troubleshooting Manual

Also see for Pocket Mod: Owner's manual Owner's manual Owner's manual Owner's manual

Contents

Razor Pocket Mod Troubleshooting Manual Manual pdf 2 page image

POCKET MOD Electric Scooter Troubleshooting GuideIssue Symptom(s) Troubleshoot Result(s) Possible Solution(s)Fuse Keeps Burning Out Check riders weight & riding conditionsReplace fuse and correct ridingconditions. (Refer to Pg 6 in OwnersManual)Loose connection(s) Reconnect Loose Connection(s)No loose connection(s) orwire(s) touching Replace Control ModuleProduct Has Short Ride TimeorProduct Runs SlowCheck riders weight & riding conditionsReplace fuse and correct ridingconditions. (Refer to Pg 6 in OwnersManual)orProduct Does Not Hold A ChargeAir pressure in front & rear tires Tire pressure low Inflate tire(s) to recommended PSI(Located on tire sidewall)Check chain tension Chain too tight Adjust chainand/or Check brake cable Brake lever feels stiff whensqueezed/cable too tightSqueeze brake lever firmly severaltimes to loosen up the brake cableUnit runs (very) slowMake sure charger is plugged into chargerport correctly & indicator lights areworking properlyCharger not plugged intocharger port correctlyCorrectly plug charger into chargerport & charge unit for 8 hrs. Refer to Pg3 in Owner's ManualSecure unit; turn power on & with NOweight on the unit, lift back end up & applythe throttleRear Wheel Spins Freely Replace BatteryRear wheel barely movesLift rear end up & manuallyspin rear wheel forwardShould spin 3-4 times w/no resistanceWheel does not spin freely Replace Rear WheelProduct Runs Intermittently Gently wiggle the wires around the throttlefor loose wires(s)Unit will go when wire(s) arewiggled/Wire(s) loose Replace ThrottleRemove battery/motor cover tocheck for loose connection(s) Loose connection(s) Reconnect Loose Connection(s)Motor engages/Unit runs again Replace Brake LeverMotor does NOT engage Replace Throttle & Control ModuleBattery shows fully charged, but goeslow after only 10-15minutes of useRemove battery/motor cover & check forloose connection(s) and/or wire(s)Note: Product ride time can be reducedany where from 10-20 minutes, on a fullycharged battery, depending on ridersweight; various riding conditions and/orif product has been properly maintainedRemove battery/motor cover & unplugbrake connector from Control Module.Secure unit; turn power on& apply throttleUnit cuts in & out while in usePower skipped several times while inuse, now will not start12/21/2006 2

/ 4

Related manuals for Razor Pocket Mod