Craftsman CMXLSBWP5 Instruction Manual

Also see for CMXLSBWP5: User manual

LITHIUM-ION RECHARGEABLEWATERPROOF LED SPOTLIGHTINSTRUCTION MANUALCMXLSBWP5345 6872191011SAVE THIS INSTRUCTION MANUALFOR FUTURE REFERENCE.Copyright © 2018 Baccus Global LLCBCThis device complies with part 15 of the FCC rules. Operation is subject to the following twoconditions: (1) this device may not cause harmful interference, and (2) this device must accept anyinterference received, including interference that may cause undesired operation.This equipment has been tested and found to comply with the limits for a Class B digital device,pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protectionagainst harmful interference in a residential installation. This equipment generates, uses and canradiate radio frequency energy and, if not installed and used in accordance with the instructions,may cause harmful interference to radio communications. However, there is no guarantee thatinterference will not occur in a particular installation. If equipment does cause harmful interferenceto radio or television reception, which can be determined by turning the equipment off and on, theuser is encouraged to try to correct the interference by one or more of the following measures:• Reorient or relocate the receiving antenna.• Increase the separation between equipment and receiver.• Connect the equipment into an outlet on a circuit different from that to which the receiver isconnected.• Consult the dealer or an experienced radio/TV technician for help.Changes or modifications not approved by the party responsible for compliance could void user’sauthority to operate the equipment.SAFETY GUIDELINES / DEFINITIONSDANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.WARNING: Indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.CAUTION: Indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury.CAUTION: Used without the safety alert symbol indicates potentially hazardous situation which, if not avoided, mayresult in property damage.RISK OF UNSAFE OPERATION. When using tools or equipment, basic safety precautions should always be followedto reduce the risk of personal injury. Improper operation, maintenance or modification of tools or equipment could resultin serious injury and property damage. There are certain applications for which tools and equipment are designed.Manufacturer strongly recommends that this product NOT be modified and/or used for any application other than forwhich it was designed. Read and understand all warnings and operating instructions before using any tool or equipment.GENERAL SAFETY WARNINGS ANDINSTRUCTIONSREAD ALL INSTRUCTIONSWARNING: Read all instructions before operating the spotlight. Failure to follow all instructions listed below mayresult in electric shock, fire and/or serious injury.INSTRUCTIONS PERTAINING TO RISK OF FIRE, ELECTRIC SHOCK, OR INJURYTO PERSONSWARNING: RISK OF FIRE, ELECTRIC SHOCK, BURST HAZARD, OR INJURY TO PERSONS – WHENUSING ELECTRICAL APPLIANCES, BASIC PRECAUTIONS SHOULD ALWAYS BE FOLLOWED, INCLUDINGTHE FOLLOWING:• LED gets HOT quickly!• Do not touch the LED at any time when operating.• Only contact trigger when turning on.• Do not touch hot lens or enclosure.• Do not remain in light if skin feels warm.• Do not operate the spotlight with a missing or damaged lens or enclosure.• The spotlight and the supplied charging cable are not toys and cannot be played with as toys. To reduce the risk ofinjury, close supervision is necessary when these units are used near children.• Use only attachments recommended or sold by the manufacturer.WARNING: TO REDUCE THE RISK OF ELECTRIC SHOCK:• Use only the USB charging cable supplied by the manufacturer to charge and recharge.• Do not store the unit or USB charging cable outdoors.• Charge indoors only. Do not expose the USB charging cable to water or any other liquidWARNING: FIRE HAZARD:• Never contact combustible material to the lens.• Keep spotlight lamp away from materials that may burn.CAUTION: TO REDUCE THE RISK OF INJURY OR PROPERTY DAMAGE:• All lights give off heat:– Do not touch lens while operating.– Keep combustibles away from spotlight lens. Extreme heat can cause fires.– Never place the light face down on any surface when lit, charging or not in use. Never store the light face downon any surface.• Never look directly into the light or shine the light into another person’s eyes.• Keep sharp objects away from lens — it can crack or break.• Do not expose this unit to extremely high temperatures.• Do not drop or throw spotlight. It contains a lithium-ion battery.• Use only with the USB charging cable provided with the unit. Plug in the charging cable at the light first, then pluginto the charging source.• After charging/recharging, disconnect the USB charging cable and wait 5 minutes before use.• Do not crush, cut, pull or expose the USB charging cable to extreme heat.• Position the USB charging cable so it does not become entangled or become a safety hazard. Keep the charging cableaway from sharp edges.• There are no user-serviceable parts inside. Do not attempt to disassemble any other parts of the unit.• To reduce risk of damage to the USB charging cable, pull by the plug rather than the cord when disconnecting.• Do not attempt to charge the unit if the USB charging cable is damaged.SPECIFIC SAFETY INSTRUCTIONS FOR LITHIUM-ION BATTERIESWARNING: TO REDUCE THE RISK OF FIRE, ELECTRIC SHOCK, BURST HAZARD, OR INJURY TOPERSONS OR PROPERTY:Lithium-ion batteries are small, compact and ideal for providing long-lasting power to this unit. However, they must beused and charged properly. Improper use can result in serious injury, fire, or death.• Lithium-ion batteries can explode in the presence of a source of ignition. Do not use the product in the presenceof an open flame.• Do not place this lithium-ion battery powered unit in fire or apply heat to it.• Do not subject this lithium-ion battery powered unit to strong impacts or shocks. The battery in this unit containssafety and protection devices which, if damaged, may cause the battery to generate heat, rupture or ignite.• Do not expose this lithium-ion battery powered unit to water or salt water, or allow the battery to get wet.• Avoid storing this lithium-ion battery powered unit in the basement, bathroom or other areas of the house that are ormay become wet or humid or where moisture may concentrate.• Do not leave this lithium-ion battery powered unit in direct sunlight, or use or store the unit inside cars in hot weather.Doing so may cause the battery to generate heat, rupture, or ignite. Using the battery in this manner may also result ina loss of performance and a shortened life expectancy.• Never charge this unit near heat or flammable objects.• NEVER THROW WATER ON A BURNING LI-ION BATTERY! If a lithium-ion battery does catch on fire,it will burn even more violently if it comes in contact with water or even moisture in the air. A fireextinguisher must be used.Battery Charging and CapacityThis unit is delivered in a partially charged state – you must fully charge it before using it for the first time.When stored at room temperature with a full charge, Li-ion batteries will will begin to discharge from the time theyare manufactured, even when unused. Deep discharges also decrease their capacity. Battery life can be extended bythe following:• Charge battery to full capacity before storage.• Optimal storage temperature for this unit is between 5°C and 20°C (41°F and 68°F).• Never discharge the battery fully.• Charge after each use.• Always charge at least once every 3-6 months if not in frequent use to prevent overdischarge.Transportation of Lithium-Ion Batteries• Always check all applicable local, national, and international regulations before transporting a unit containing aLithium-Ion battery.• Transporting an end-of-life, damaged, or recalled battery may, in certain cases, be specifically limited or prohibited.INSTRUCTIONS PERTAINING TO WATERPROOF SPOTLIGHTSThe rubber “O” ring acts to preserve the waterproof qualities of the spotlight. The “O” ring seals the end cap to preventwater from entering the gap. An undamaged rubber “O” ring, rubber bezel and lens, and proper sealing of the end capbefore use are very important.CAUTION: TO REDUCE THE RISK OF PROPERTY DAMAGE:• Attempting to remove the rubber “O” ring; use of the unit with a damaged “O” ring, rubber bezel or lens; impropersealing of the waterproof end cap; and/or submerging this unit in depths greater than 6 feet may cause the unit to nolonger be waterproof. Do not submerge the unit if these conditions exist or the unit could sustain permanent damage.• Submerging this unit in depths greater than 6 feet and/or operating it in water temperature other than between41ºF and 104ºF (5ºC and 40ºC) could result in leakage, warping or malfunction, causing permanent damage to thespotlight.SAVE THESE INSTRUCTIONSINTRODUCTIONCongratulations on purchasing your new Craftsman® Spotlight. Read this Instruction Manual and followthe instructions carefully before using your new spotlight.FEATURES1. LED bulb2. Rubber bezel3. On/off trigger4. Grip handle5. Micro-USB charging port (for use with the USB Charging Cable)6 Battery/charge status LED indicator7. Translucent waterproof end cap (see detailed view in the “Reading the Battery/Charge Status LED Indicator” section)8. Rubber O-ring9. USB charging cable10. Regular USB plug11. Micro-USB plugREADING THE BATTERY/CHARGE STATUS LED INDICATORThe battery and charging status LED indicator is located directly above the micro-USB charging port under thewaterproof end cap on the back of the unit.DOT ICON (FOR ALIGNMENTTO THE TRIANGULAR ICONON THE END CAP)TRIANGULAR ARROWICON (FOR ALIGNMENTTO THE DOT ICON ON THEREAR OF UNIT)END CAP DETAILIt lights or flashes in three colors to indicate the following:When charging:Green: Battery is in a fully charged state.Green (flashing): Battery is in a high partially charged state.Orange (flashing): Battery is in a low partially charged state.Red (flashing): Battery needs to be recharged.Red (flashing rapidly): The battery of the unit is overheated due to extensive use or recharging. The chargingprocess will stop at this stage and will automatically resume after a cool down period.When operating:Green: Battery is operating at full voltage.Orange: Battery is operating at partial voltage.Red: Battery is operating at low voltage, and should be recharged or the built-in low voltage protection will be activatedand the unit will automatically shut down shortly.Red (flashing rapidly): The battery of the unit is overheated (due to extensive use or recharging), or is too cold (theambient temperature has dropped below -20°C). Operation will stop at this stage.CHARGING/RECHARGING THE SPOTLIGHTThis unit is shipped in a partially charged state. Charge unit after purchase and BEFORE first use until the battery/chargestatus LED indicator lights green.Recharge after each use until the battery/charge status LED indicator lights green.IMPORTANT: When the unit is not in use, we recommend that the battery is charged at least every3 to 6 months.CAUTION: TO REDUCE THE RISK OF INJURY OR PROPERTY DAMAGE:• Make sure the unit is thoroughly dry before charging or recharging. If the unit has been submerged, wipe it dry with asoft cloth before opening the end cap. If water leaks into the charging port, the unit can sustain permanent damage.• Never place the light face down on any surface when charging.• Failure to keep the battery charged will cause permanent damage and result in poor performance.Charging/recharging using the USB charging cable and a device with a USBpower port (not supplied)1. Make sure the spotlight is off.2. Unscrew (counterclockwise) the waterproof end cap on the back of the unit and remove it.3. Insert the micro-USB plug of the USB charging cable into the micro-USB charging port on the back of spotlight.4. Insert the regular USB plug of the USB charging cable into a device’s functional USB power port. The battery/chargestatus LED indicator will light or flash in one of three colours (as described in the “Reading the Battery/ChargeStatus LED Indicator” section) to indicate the charging status.5. Charge until the battery/charge status LED indicator lights green.6. When charging is complete, disconnect the USB charging cable from the device’s USB power port and the spotlight.Store the cable in a safe place.7. Replace the end cap on the unit, screwing clockwise until the triangular arrow on the end cap is pointing to the doticon on the rear of unit. Make sure it fits securely, but do NOT overtighten.OPERATING THE SPOTLIGHTThe On/Off Trigger turns the unit on and off, and is also used to choose either the high or low brightness setting.CAUTION: DO NOT OPERATE WHILE CHARGING.Disconnect the charging cable or adapter, then select the light mode as follows:• Press the On/Off trigger once to use the spotlight in its high (brightest) setting.• Press the On/Off trigger again within 5 seconds to use the spotlight in its low (dimmest) setting.• Press the On/Off trigger a third time to turn the unit off. or• Press the On/Off trigger once to use the spotlight in its high (brightest) setting.• Press the On/Off trigger again after 5 seconds to turn the unit off.Note: The battery/charge status LED indicator will light in one of three colors (as described in the “Reading theBattery/Charge Status LED” section) to indicate the battery status. It is visible through the translucent waterproofend cap.CARE AND MAINTENANCEAll batteries lose energy from self-discharge over time and more rapidly at higher temperatures. When the unit is not inuse, we recommend that the battery is charged at least every 3 to 6 months.If the unit gets dirty, gently clean the outer surfaces of the spotlight unit with a soft cloth moistened with a mild solutionof water and detergent.There are no user-replaceable parts. Periodically inspect the condition of adapters, connectors and wires. Contactmanufacturer to replace any components that have become worn or broken.Battery replacement/disposalBATTERY REPLACEMENTThe battery should last the service life of the unit. Service life is dependent on a number of factors including but notlimited to the number of recharge cycles, and proper care and maintenance of the battery by the end user. Contactmanufacturer for any information you may need.SAFE BATTERY DISPOSALContains a lithium-ion battery, which must be disposed of properly. Recycling isrequired. Failure to comply with local, state and federal regulations can result infines, or imprisonment.Please recycle.WARNINGS:• Do not dispose of the battery in fire as this may result in an explosion.• Before disposing of the battery, protect exposed terminals with heavy-duty electrical tape to prevent shorting (shortingcan result in injury or fire).• Do not expose battery to fire or intense heat as it may explode.TROUBLESHOOTINGThe spotlight will not charge• Check that the spotlight is turned off.• Check the connection to the spotlight and the power source. Make sure there is good contact.• Make sure the power source is functioning properly.• The unit may have shut down to protect the battery from overheating after a long period of operation or charging.Unplug the USB charging cable from the power source and the spotlight. Allow the spotlight to cool down for a periodbefore resuming charging.The spotlight will not operate• Make sure the On/Off Trigger has been pressed to turn the spotlight on.• The internal battery may be completely discharged. Charge the unit following the directions given in this manual.• The unit may have shut down to protect the battery from overheating after a long period of operation or charging; orthe ambient temperature has dropped below –20°C. Allow the spotlight to cool down or warm up for a period beforeresuming operation.• If the ambient temperature is too hot or too cold the spotlight will not operate.If the unit does not charge or operate after taking the steps given above, contact the manufacturer at 888-331-4569.ACCESSORIESRecommended accessories for use with your tool may be available from the manufacturer. If you need assistanceregarding accessories, please contact the manufacturer at 888-331-4569.WARNING: The use of any accessory not recommended for use with this appliance could be hazardous.SERVICE INFORMATIONWhether you need technical advice, repair, or genuine factory replacement parts, contact the manufacturer at 888-331-4569.ONE-YEAR LIMITED WARRANTYThe manufacturer warrants this product against defects in materials and workmanship for a period of ONE (1) YEAR fromthe date of retail purchase by the original end-user purchaser (“Warranty Period”).If there is a defect and a valid claim is received within the Warranty Period, the defective product can be replaced orrepaired in the following ways: (1) Return the product to the manufacturer for repair or replacement at manufacturer’soption. Proof of purchase may be required by manufacturer. (2) Return the product to the retailer where product waspurchased for an exchange (provided that the store is a participating retailer). Returns to retailer should be made withinthe time period of the retailer’s return policy for exchanges only (usually 30 to 90 days after the sale). Proof of purchasemay be required. Please check with the retailer for their specific return policy regarding returns that are beyond thetime set for exchanges.This warranty does not apply to accessories, bulbs, fuses and batteries; defects resulting from normal wear and tear,accidents; damages sustained during shipping; alterations; unauthorized use or repair; neglect, misuse, abuse; andfailure to follow instructions for care and maintenance for the product.This warranty gives you, the original retail purchaser, specific legal rights and you may have other rights which vary fromstate to state or province to province. This product is not intended for commercial use.Please complete the Product Registration Card and return within 30 days from purchase of the product to: Baccus GlobalLLC, One City Centre, 1 North Federal Highway, Suite 200, Boca Raton, FL 33432. Baccus Global LLC, toll-freenumber: 888-331-4569.SPECIFICATIONSLightBulb: 5 watt LED bulbBattery: Lithium-Ion, 3.6 V DCInput: 5V DC, 1ATo purchase optional accessories, contact the manufacturer at 888-331-4569.Imported by Baccus Global LLC,One City Centre, 1 North Federal Highway, Suite 200, Boca Raton, FL 33432www.Baccusglobal.com 888-331-4569RD091018

/ 2

Related manuals for Craftsman CMXLSBWP5