Baja motorsports DR125 Owner's Manual

Also see for DR125: Owner's manual Setup instructions

Baja motorsports DR125 Owner's Manual Manual pdf 27 page image

24TROUBLESHOOTINGThis troubleshooting guide is provided to help you to find the cause of somecommon complaints.COMPLAINT: Engine is hard to start or does not start at all. Something isprobably wrong with the fuel system or ignition system.Fuel Supplying Check1. Make sure there is adequate fuel in the fuel tank.2. Check that the engine stop switch is in the “RUN “ position.3. Check that the fuel valve is in the “ON” position.4. Make sure there is enough fuel reaching the carburetor from the fuel tank.a. Loosen the drain screw which is located under the carburetor. Drain thefuel from the carburetor into a container.b. Tighten the drain screw.c. Run the engine for a few seconds. Shut off engine.d. Loosen the drain screw and check that the carburetor is filled back upwith fuel.e. If fuel is reaching the carburetor, the ignition system should be checkednext.WARNINGDraining fuel from the carburetor could be hazardous.Fuel could catch fire if you do not handle it properly.When draining the carburetor, be sure to shut the engine off. Do notsmoke, and never drain or refuel in an area where there are open flamesor sparks. Do not spill the fuel or you may create a fire hazard. Disposeof drained fuel properly.CAUTIONFailing to troubleshoot a problem correctly would damage your Dirt Bike.Improper repairs or adjustments may damage the vehicle. Such damagemay not be covered under warranty. If you are not sure about the properaction, consult your authorized service center or BAJA INC. about theproblem.!