AGA OC Installation Instructions Manual

Also see for OEB: User instructions

AGA OC Installation Instructions Manual Manual pdf 1 page image

With specific exceptions, the installing of any type of Agacooker is subject to the respective directions contained inthe current Building Regulations and the BuildingStandards (Scotland) (Consolidation).Practical guidance to meeting such requirements arecontained in the Approved Document J 1/4/5 - HeatProducing Appliances in Schedule 1 of the BuildingRegulations.In addition, Planning Permission may need to beobtained, which should be applied for separately.THIS APPLIANCE IS A CONTROLLED SERVICE BYDEFINITION AND REQUIRES EITHER FITMENTUNDER THE REMIT OF BUILDING CONTROL ORINSTALLATION BY AN OFTEC REGISTERED 105TECHNICIAN (CLASSED AS A COMPETENTPERSON) WHO CAN SELF CERTIFY HIS OWNWORKS.Such provisions for oil burning appliances are dealt with inSection 4 of the Building Regulations where the Aga OilFired Cooker, compares as follows:Hearths1. Section 4 - Para 4.24.A Constructional Hearth should be provided tosupport the applianceShielding of the Appliance2. Section 4 - Para 4.28.The surface temperatures of the sides and back ofthe appliance do not exceed 100°C and do nottherefore require shielding as described in Section 3 -Para 3.2 (a) or (b) of the Approved Document.Heat Exchangers – Models OCB and OEB onlyThis cast iron heat exchanger is 'listed' by the NationalWater Council and, when correctly installed, complieswith Water Byelaws and Regulations.The heat exchanger must be connected to a copperdouble feed indirect cylinder to BS 1566 Part 1 only.NOTE: AGA OIL FIRED COOKERS ARE DELIVEREDEX-WORKS UNASSEMBLED. ASSEMBLY ISUNDERTAKEN ON SITE BY THE AUTHORISED AGADISTRIBUTOR.FuelThese appliances must only be used with CommercialKerosene current issue to BS 2869 : Class C2 suitable forvapourising burners.Cooker Base or HearthIt is essential that the base or hearth on which the cookerstands should be level, and be capable of supporting thetotal weight of the respective cooker:Models OC and OCB - 406 kgModels OE and OEB - 584 kgInstallation Instructionsfor Aga Oil Fired CookerModels OC, OCB, OE and OEBConsumer Protection Act 1987As responsible manufacturers we take care to make sure that ourproducts are designed and constructed to meet the required safetystandards when properly installed and used.IMPORTANT NOTICE: PLEASE READ THE ACCOMPANYINGWARRANTY.Any alteration that is not approved by Aga, could invalidate theapproval of the appliance, operation of the warranty and could alsoaffect your statutory rights.Control of Substances - Health and SafetyImportantThis appliance may contain some of the materials that are indicatedbelow. It is the Users/Installers responsibility to ensure that thenecessary personal protective clothing is worn whenhandling, whereapplicable, the pertinent parts that contain any of the listed materialsthat could be interpreted as being injurious to health andsafety, see below for information.Firebricks, Fuel beds, Artificial Fuels - when handling usedisposable gloves.Fire Cement - when handling use disposable gloves.Glues and Sealants - exercise caution - if these are still in liquidform use face mask and disposable gloves.Glass Yarn, Mineral Wool, Insulation Pads, Ceramic Fibre,Kerosene Oil - may be harmful if inhaled, may be irritating to skin,eyes, nose and throat. When handling avoid inhaling and contactwith skin or eyes. Use disposable gloves, face-masks and eyeprotection. After handling wash hands and other exposed parts.When disposing of the product, reduce dust with water spray,ensure that parts are securely wrapped.PRE-INSTALLATION ADVICEADDITIONAL PROVISIONSFOR AGA COOKERSAGA OIL COOKEROCIDLING OIL cc per minuteRATE - LOW FIRE Heat Input (Btu/h)COOKING OIL cc per minuteRATE - HIGH FIRE Heat Input (Btu/h)Approximate Weekly LitresOil Consumption GallonsBOILER OUTPUTMaximum Operating Pressure 1.8 Bar OE OEBOCB90 1353.7 5.0 6.0 4.4 6.07,690 10,390 12,470 9,145 12,4707.0 8.0 8.0 7.0 8.014,550 16,630 16,630 14,550 16,63040.0 60.0 65.15 50.9 68.48.8 13.3 14.35 11.2 15.051.3 kW 2 kW 0.9kW4,435 Btu 6,824 Btu 3,070 Btu04/07 EINS 5109491